Got a new used scooter need help bad By slipout2002 (Read 853 times)

[slipout2002]

ok scooter has around 6000 miles it is only 49cc and i know that i am getting gas to the carb just not through the carb i took off the carb and cleaned it there is a electronic neadle that mounts to the top back on the left of the carb i think it may be a fuel shut off but not shure i cant get it to move the neadle when cycleing the scoot to on or off or even while turning it over any ideas please i can use all the help i can get

[skooter]

Mar 15, 2011 13:50:01 GMT -6 slipout2002 said:

ok scooter has around 6000 miles it is only 49cc and i know that i am getting gas to the carb just not through the carb i took off the carb and cleaned it there is a electronic neadle that mounts to the top back on the left of the carb i think it may be a fuel shut off but not shure i cant get it to move the neadle when cycleing the scoot to on or off or even while turning it over any ideas please i can use all the help i can get

It sounds like you are talking about the electric choke/auto enricher.
It will move very slowly, and once the scoot is fully warmed up it was shut off.

Have you cleaned the carb jets with guitar string wire? Its a VERY thin wire you will need. They get clogged up.

Welcome to the Forum, I am new myself, but I'll try and help if I can.

Lots fo great advice and members here, they will chime in i'm sure.

[Alleyoop]

Welcome to the Forum,
Sounds like you need to do a couple things.
One is clean out your Carb, and if it is a 4 Stroke adjust your valves Intake .004 Exhaust .005.
You need to take the carb off and clean it out really good. Get a Can of Carb Cleaner they come with a long thin straw and spray inside any holes you find. Spray should come out from out of the passages that they lead to.
The Pilot Jet if clogged will stop it from starting and idleing good.
The Main Jet comes in to play around mid-to-full throttle.
Alleyoop

[slipout2002]

i did not use a wire but with the carb cleaner i shot through it had a good stream coming out of the carb i cant even get the motor to sputter or atempt to start

[Bashan]

If it won't sputter at all you may need to see is you're getting a spark. Rich

[sprocket]

>>i did not use a wire

Did you physically remove both gets and run a wire through them? Then the jets are probably still dirty.

[slipout2002]

i do have spark and i went back and ran a wire through and still no better i double checked to see if i was maybe flooding out in side of the cylinder is void of gas any thoughts i realy apreaciate the help

[kz1000st]

Take out spark plug, spray in starter fluid or gas and replace spark plug and see if it runs for a few seconds. If yes, fuel delivery problem. If no, electrical problem.