new enGine is burning oil By seanstr (Read 2,788 times)

[seanstr]

Brand new engine started burning oil at only 45 miles. I never did wot. What is wrong, it's white light blue tint of smoke. Help please.

[h3nry]

A new engine can burn oil from the start and will do so for a while. But if it suddenly started after 45(kilometers) then it may be a leak past the rings(worst case) or a leak past the head gasket (not so bad, half hour to an hour to replace) or could even just be the rings are not seating good enough, I say go drive it and open her up, go wot for a quarter mile after a good warm up then check if it still is burning oil

[seanstr]

What about driving it even slower? Say 20- 30 mph. I can't get to complete wot without doing an adjustment to the throttle cable. what about the emissions? I have an oil smog collector. The hose comes from the head cover, goes straight to the emissions canister, then back to the air breather assembly. If that is full?

[h3nry]

Does it smoke during idle? If so slower wont help. The combustion in the engine forces the rings out, that's why I said to go wot, to force them out against the cylinder and make then seat better.

First thing I did with my new scoot was warm it up good by driving slow then go wot.for about a half mile at a time..I was burning oil at first but it stopped fast

[seanstr]

At this point I can't hurt, I'll adjust the cable to get it to do the wot

[seanstr]

Ok, do, I have replaced hoses, also fixed throttle cable so I can do wot, & put heavy thick oil additive. It it's smoking much less. Will try wot, tomorrow.

[Alleyoop]

Yes, you have to run them up to good rpms do some 40-50mph runs so the rings get seated evenly.
Alleyoop

[sprocket]

Use dino oil 15w/40 no additives...how much oil do you have in it? Sounds to me like you have too much and you are getting a pressurization of the sump...

In a 150 cc 750 ml is enough, about 3/4 of a quart...

[seanstr]

No it is burning oil, always low.

[Alleyoop]

When new they ususally will burn some oil until the rings seat well. So ride it vary the speeds but get it up to some good rpms DON'T Baby it to much. The rings need some good rpms to seat well. If after a hundred or so miles it is still blowing smoke then I would say you have a problem.
Alleyoop

[sprocket]

Is this a Coke Can engine from Ebay? If you bought from a reputable dealer you should be able to exchange it..worth a try...

[seanstr]

None will take back, it's monster scooter parts, they are butt munches

[sprocket]

Well give it some more use and see what happens...make certain you top up the oil on the dipstick so you don't run too low.

[seanstr]

yeah I keep a buncha oil inside my a scooter at all times

[seanstr]

I have much oil in scooter.